Cornelius PR150 Manual do Utilizador

IMPORTANT:TO THE INSTALLER.It is the responsibility ofthe Installer to ensure thatthe water supply to thedispensing equipment isprovided with protecti

7620918702FIGURE 2. FLOW DIAGRAM

8620918702THIS PAGE LEFT BLANK INTENTIONALLY

9 620918702MAINTENANCEThe following dispenser maintenance should be performed at the intervals indicated.DAILY (or as required)Remove foreign material

106209187021. Remove cover from the dispensing valve by lifting the front cover up 1/4 inch and pulling forward.2. Install syrup diversion tube assemb

11 6209187022. Install syrup diversion tube assembly on the dispensing valve by pushing the rubber end of the syrup diver-sion tube onto the syrup out

12620918702696667657377FIGURE 4. AUGER ASSEMBLYCLEANING AND SANITIZING INSTRUCTIONSWARNING: Disconnect electrical power to the dispenser before cleani

13 620918702C. Wash cup rest with soap solution and rinse with potable water. Install cup rest in drip tray.D. Clean all exterior surfaces of the disp

14620918702J. Reassemble the agitator assembly and disc into the hopper. Make certain the retaining screw is tight.K. Using a mechanical spray bottle

15 62091870211. For post-mix valves, remove the nozzle and syrup diffuser and clean them in a mild soap solution.Rinse with clean water and reassemble

16620918702FIGURE 7. WIRING DIAGRAM

i620918702TABLE OF CONTENTSSAFETY INFORMATION 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

17620918702FIGURE 8. LADDER DIAGRAM

18620918702THIS PAGE LEFT BLANK INTENTIONALLY

19620918702TROUBLESHOOTINGIMPORTANT: Only qualified Personnel should service internal components or electrical wiring.WARNING: If repairs are to be ma

20620918702Trouble RemedyProbable CauseAGITATOR TURNS, AUGERDOES NOT TURN (CONT’D)C. Inoperative rectifier. C. Replace rectifier.D. Ice jam. D. Clear

21 620918702ILLUSTRATED PARTS LIST123412813961711581334959122133791188978871141421411348611511696859812124.7475101136105110112109838891171271038090168

2262091870214551076391140124126651258412413812072119732527373873929104113241136511126 329595525310212336952295441007035473536309513069 20 18 19 979551

23 620918702675668557457715466616081627664431084950462815361353535362314412936

24620918702PR150BC ASSEMBLYItemNo. Part No. Name1 1919 Mounting Block Ass’y, UF-12 1950 Cover, Valve, Back3 1951 Cover, Valve, Front4 1966 Dispensing

25 620918702PR150BC ASSEMBLY (CONT’D)ItemNo. Part No. Name45 90432 Label, Warning, Disconnect46 90580 Label, Identification Data47 90629 Label, Clean

26620918702PR150BC ASSEMBLY (CONT’D)ItemNo. Part No. Name87 620045724620045727Base, Tower LHBase, Tower RH88 620045904 Bracket, Dispense Switch89 620

ii620918702TABLE OF CONTENTSFIGURE 1. MOUNTING TEMPLATE 6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FIGURE 2. FLOW DIAG

27 620918702PR150BC ASSEMBLY (CONT’D)ItemNo. Part No. Name132 620704604 Fitting, 3/8 By 1/2 MPT133 620708524 Cup Rest134 620705201 Pushon Nut, 3/1613

28620918702WARRANTYIMI Cornelius Inc. Products Company warrant that all equipment and parts are free from defects in material andworkmanship under nor

www.cornelius.com(800) 238-3600IMI CORNELIUS INC.

1 620918702SAFETY INFORMATIONRecognize Safety InformationThis is the safety-alert symbol. When you see thissymbol on our machine or in this manual, be

2620918702THIS PAGE LEFT BLANK INTENTIONALLY

3620918702SAFETY PRECAUTIONSThis dispenser has been specifically designed to provide protection against personal injury and eliminate contamination of

4620918702THIS PAGE LEFT BLANK INTENTIONALLY

5 620918702INSTALLATION INSTRUCTIONS COUNTER HEIGHT(INCHES)DISPENSERDEPTH(INCHESAVAILABLE SPACE BELOW DISPENSER(INCHES)USE KIT NO.30 29 1 CONSULT FACT

6620918702FOOT PRINT OF UNITON COUNTERTOP29 – 5/827–3/1625–3/431–7/8THE ABOVE FIGURE SHOWS THE REQUIRED CUTOUT FOR PLACING THE ICE DISPENSER INTO A CO