Cornelius REMCOR 1550 Manual do Utilizador Página 1

Consulte online ou descarregue Manual do Utilizador para Soluções para fazer cubos de gelo Cornelius REMCOR 1550. Cornelius REMCOR 1550 User's Manual Manual do Utilizador

  • Descarregar
  • Adicionar aos meus manuais
  • Imprimir
Vista de página 0
Installation Manual
1550 UNIVERSAL BEER DISPENSER
(R-404A REFRIGERANT)
PRINTED IN U.S.A
IMI CORNELIUS INC; 1998–99
IMI CORNELIUS INC g One Cornelius Place g Anoka, MN 55303-6234
Telephone (800) 238-3600 Facsimile (612) 422-3246
Part No. 569000246
August 11, 1998
Revised: June 11, 1999
Control Code A
THIS DOCUMENT CONTAINS IMPORTANT INFORMATION
This Manual must be read and understood before installing or operating this equipment
Vista de página 0
1 2 3 4 5 6 ... 35 36

Resumo do Conteúdo

Página 1 - (R-404A REFRIGERANT)

Installation Manual1550 UNIVERSAL BEER DISPENSER(R-404A REFRIGERANT)PRINTED IN U.S.AIMI CORNELIUS INC; 1998–99IMI CORNELIUS INC g One Cornelius Pla

Página 3 - TABLE OF CONTENTS (cont’d)

6569000246THIS PAGE LEFT BLANK INTENTIONALLY

Página 4 - SAFETY INFORMATION

7 569000246INSTALLATIONThis section covers unpacking and inspection, selecting location, installing Unit, preparing for operation, andoperation.UNPACK

Página 5

85690002462. The Unit must be installed near a properly grounded electrical outlet with proper electrical require-ments.The electrical circuit must be

Página 6 - 2569000246

9 5690002466. Make sure the main power switch (115 VAC, 60 Hz Unit), located on back side of the Unit, is in the “OFF”(down) position.7. Plug Unit pow

Página 7 - GENERAL INFORMATION

105690002463. Open the CO2 cylinder shutoff valve slightly to allow the primary CO2 regulator to fill with gas, then openthe valve fully to back-seat

Página 8 - THEORY OF OPERATION

56900024611OPERATOR’S INSTRUCTIONSThis section covers operating controls, pre-operation check, Unit operation, and maintenance procedures thatmay be p

Página 9

569000246 12BEER FAUCET (2)UNIT POWER SWITCH(115 VAC, 60 HZ UNIT ONLY)DRIP TRAY/CUP RESTFIGURE 3. 1550 UNIVERSAL BEER DISPENSEROPERATING CLEARANCESChe

Página 10

56900024613 An excessive accumulation of dust, lint, and grease on the condenser coil will restrict air flow through the coilwhich will decrease cooli

Página 12 - INSTALLATION

i569000246TABLE OF CONTENTSPageSAFETY INFORMATION 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Página 13

569000246 14THIS PAGE LEFT BLANK INTENTIONALLY

Página 14 - PREPARING UNIT FOR OPERATION

56900024615SERVICE AND MAINTENANCEThis section describes the service and maintenance procedures to be performed on the Unit.IMPORTANT: Only qualified

Página 15 - UNIT OPERATION

569000246 16UNIT BEER INLETLINES (2)POWERCORDTOP COVERBEER FAUCET (2)CUP RESTDRIP TRAYAIR INTAKERETAININGSCREW (4)ACCESS GRILLE (4)DRIP TRAYDRAIN HOSE

Página 16 - OPERATOR’S INSTRUCTIONS

56900024617BEER INLETLINES (2)ELECTRICALCONTROL BOXPOWER CORDRETAININGSCREWTERMINALBLOCKCONDENSERCOILUNIT POWERSWITCH(115 VACUNIT ONLY)COMPRESSORCONDE

Página 17 - OPERATING CLEARANCES

569000246 18Adjusting Beer Kegs Secondary CO2 Regulators.Beer kegs secondary CO2 regulators pressures adjustments require calculations of each beer sy

Página 18 - SANITIZING BEER SYSTEMS

569000246192. Remove four screws securing air intake grille on the Unit front panel, then remove the grille.3. Vacuum or use a soft brush to clean the

Página 19

569000246 208. Using a fiber brush, carefully clean mineral deposit build-up from the agitator motor shaft and the ice banksensing bulb.9. Rinse all p

Página 20 - 569000246 14

569000246215. Connect tank containing detergent solution into the beer system.6. Place waste container under applicable beer faucet.7. Activate the be

Página 21 - SERVICE AND MAINTENANCE

569000246 22WARNING: CO2 displaces oxygen. Strict attention must be observed in the prevention ofCO2 (carbon dioxide) gas leaks in the entire CO2 and

Página 22

56900024623CLEANING CO2 GAS CHECK VALVE(see Figures 2 and 7) CO2 gas check valves must be inspected and serviced at least once a year under normal con

Página 23

ii569000246TABLE OF CONTENTS (cont’d)PageSERVICE AND MAINTENANCE 15. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Página 24 - CLEANING CONDENSER COIL

569000246 24FIGURE 8. WIRING DIAGRAM

Página 25 - CLEANING WATER TANK

25 569000246TROUBLESHOOTINGIMPORTANT: Only qualified Personnel should service internal components or electrical wiring.WARNING: If repairs are to be m

Página 26 - CLEANING AND SANITIZING

26569000246Trouble RemedyProbable CauseDISPENSED BEER FLOWRATE TOO HIGH.A. Beer faucet not properlyadjusted for beer flow rate.A. Adjust dispensed bee

Página 27 - REPLENISHING CO

27 569000246Trouble Probable Cause RemedyTROUBLESHOOTING COOLING UNIT REFRIGERATION SYSTEMCOMPRESSOR DOES NOTOPERATE.A. Glycol (coolant) sufficientlyc

Página 28 - REPLENISHING BEER SUPPLY

28569000246Trouble RemedyProbable CauseREFRIGERATIONCOMPRESSOR NOTOPERATINGA. Refrigeration systemoverheated. Cloggedcondenser coil air intake filter

Página 29 - GAS CHECK VALVE

29 569000246IMI CORNELIUS INC.ONE CORNELIUS PLACEANOKA, MN. 55303–6234TELEPHONE (800) 238–3600FACSIMILE (612) 422–3232WARRANTYIMI Cornelius Inc. warra

Página 30 - FIGURE 8. WIRING DIAGRAM

IMI CORNELIUS INC.CORPORATE HEADQUARTERS:One Cornelius PlaceAnoka, Minnesota 55303-6234(612) 421-6120(800) 238-3600301137000

Página 31 - TROUBLESHOOTING

1 569000246SAFETY INFORMATIONRecognize Safety InformationThis is the safety-alert symbol. When you see thissymbol on our machine or in this manual, be

Página 33

2569000246THIS PAGE LEFT BLANK INTENTIONALLY

Página 34

3 569000246GENERAL INFORMATIONIMPORTANT: To the user of this manual – This manual is a guide for installing, operating, and main-taining this equipmen

Página 35 - WARRANTY

4569000246Table 1. Design Data (cont’d)Electrical Requirements:Operating Voltage See Unit NameplateCurrent Draw See Unit NameplateTHEORY OF OPERATION(

Página 36 - (800) 238-3600

5569000246CO2 GASCHECK VALVE (2)BEER KEG (2)CO2 CYLINDERLINE LEGENDBEERCO2PRIMARY CO2REGULATORBEER KEG SECONDARYCO2 REGULATOR (2)CO2 SHUTOFFVALVE (2)B

Comentários a estes Manuais

Sem comentários